S.K.Y-Bulletins

Closed Thread Subscribe

Thread Tools

Search this Thread

Rate Thread

03-09-2013, 04:53 PM

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

S.K.Y-Bulletins

For those Mazda's with SkyActiv Piston Engines.

As always be careful that you match VIN # first (where shown) to see if your car is part of the TSB concern.

Discussion Thread for these TSB's is here...https://www.rx8club.com/general-auto...ssions-248772/

Attached Files

ATF-FZ REQUIRED FOR SKYACTIV DRIVE 6-SPEED AUTOMATIC TRANSAXLE.pdf (177.3 KB, 9453 views)

AUDIO FUSE (15A) INSTALLATION AT PDI.pdf (246.1 KB, 542 views)

Battery Used for i-stop System.pdf (393.1 KB, 12605 views)

BUMPER COVER (OR FASCIA) REPAIR REFINISHING NOTICE.pdf (16.6 KB, 432 views)

Basic i-ELOOP knowledge.pdf (562.2 KB, 1691 views)

03-09-2013, 04:55 PM

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

Next..

Attached Files

CARGO COMPARTMENT LIGHT BULB REPLACEMENT CAUTION.pdf (71.5 KB, 939 views)

Charging System Warning Light Illumination with DTC P0A94_00_U3000_49.pdf (84.5 KB, 650 views)

CHATTER NOISE FROM STEERING COLUMN COVER.pdf (51.1 KB, 1399 views)

Clicking noise when opening trunk lid.pdf (155.5 KB, 448 views)

CX-5 Chirp noise from rear right over 100 km_h (62 MPH).pdf (170.2 KB, 480 views)

03-09-2013, 04:58 PM

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

Attached Files

CONDENSATION FOG IN FRONT AND REAR COMBINATION LIGHTS.pdf (565.9 KB, 483 views)

DOOR GLASS RUN CHANNEL OUT OF POSITION.pdf (100.6 KB, 534 views)

Driver Seat Cushion Warmer as Service Part.pdf (175.3 KB, 502 views)

DRIVER-SIDE POWER DOOR MIRROR VIBRATION.pdf (848.3 KB, 1899 views)

ENGINE START STOP PROCEDURE WITH ROOM FUSE REMOVED.pdf (109.2 KB, 496 views)

03-09-2013, 05:01 PM

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

More...

Attached Files

ENGINE WILL NOT START WHEN USING REMOTE ENGINE STARTER (RES).pdf (21.6 KB, 644 views)

EXCESSIVE CONDENSATION OR WATER WITHIN THE HEADLAMP ASSEMBLY.pdf (60.5 KB, 577 views)

FRONT SEAT CUSHION COMING OFF SEAT FRAME - (CLOTH SEAT ONLY).pdf (460.4 KB, 632 views)

Handling Caution for Trailer Transportation.pdf (177.2 KB, 346 views)

HOOD VIBRATION WHILE DRIVING AT HIGHWAY SPEED.pdf (629.8 KB, 975 views)

03-09-2013, 05:03 PM

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

more....

Attached Files

HORN SOUNDS BY ITSELF.pdf (55.2 KB, 375 views)

How to CHECK SA-DIESEL Engine Oil Level.pdf (78.3 KB, 456 views)

KNOCKING RATTLING NOISE FROM PASSENGER SEAT BACK -.pdf (376.6 KB, 459 views)

LIFTGATE OPENER SWITCH INOPERATIVE.pdf (155.6 KB, 588 views)

MAZDA SERVICE PROGRAM (MSP38) - ROUGH IDLE AND ENGINE STALL DURING.pdf (25.4 KB, 1294 views)

03-09-2013, 05:04 PM

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

Next.

Attached Files

MAZDA SERVICE PROGRAM (MSP39) - MIL ILLUMINATION WITH DTC P012600.pdf (29.2 KB, 815 views)

NEW MODEL SERVICE CAUTIONS CX-5.pdf (112.2 KB, 612 views)

NEW MODEL SERVICE CAUTIONS Mazda 6.pdf (197.9 KB, 600 views)

PASSENGER AIRBAG DEACTIVATION (PAD) INDICATOR.pdf (109.7 KB, 955 views)

Skyactiv DTC P2610_00 stored.pdf (115.5 KB, 349 views)

03-09-2013, 05:06 PM

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

more..

Attached Files

POOR APPEARANCE OF GLOVE COMPARTMENT.pdf (87.0 KB, 476 views)

RATTLE NOISE AT IDLE SPEED DURING ENGINE WARM UP.pdf (20.8 KB, 602 views)

RATTLE NOISE FROM INSTRUMENT PANEL ANDOR CREAK NOISE FROM APILLAR.pdf (401.3 KB, 973 views)

RATTLING NOISE FROM LIFTGATE WHEN GOING OVER A BUMP.pdf (78.8 KB, 2421 views)

REAR CENTER SEAT BRACKET COVER COMES OFF.pdf (139.8 KB, 357 views)

03-09-2013, 05:09 PM

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

next..

Attached Files

Right side of front bumper is lifted up from fender.pdf (269.3 KB, 458 views)

ROUGH IDLE WITH MIL ON AND DTC P0015 P0524.pdf (187.3 KB, 1325 views)

Rough idle with MIL On with DTC P0015 _ P0524.pdf (103.1 KB, 545 views)

SHIFT SHOCK.pdf (122.8 KB, 939 views)

SHIFT SHOCKLONG TIME LAG WHEN SHIFTING INTO REVERSE.pdf (21.0 KB, 946 views)

03-09-2013, 05:11 PM

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

more..

Attached Files

SQUEAK NOISE FROM ENGINE COMPARTMENT.pdf (80.9 KB, 707 views)

STAINS FOUND ON PAINT DURING PDI.pdf (117.4 KB, 358 views)

STEERING SHIMMY OR SHAKE AT 50 - 80 MPH.pdf (56.2 KB, 481 views)

TAPPING NOISE COMING FROM FRONT SEAT BACK.pdf (192.1 KB, 370 views)

TAPPING NOISE WHERE EDGE OF DASHBOARD MEETS WINDSHIELD.pdf (216.2 KB, 2581 views)

03-09-2013, 05:15 PM

#10

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

more..................

Attached Files

TIRE PRESSURE MONITORING SYSTEM (TPMS) INITIALIZATION PROCESS.pdf (504.6 KB, 743 views)

Tire Pressure Monitoring System (TPMS) Warning Light Illuminating Unintentionally (Mis-use Preve.pdf (182.6 KB, 998 views)

TIRE PRESSURE MONITORING SYSTEM (TPMS) WARNING LIGHT ILLUMINATION.pdf (137.7 KB, 2216 views)

TOMTOM NAVIGATION SYSTEM SERVICE INFORMATION.pdf (18.3 KB, 742 views)

CX-5 Unable to Fold Rear Seatback by Remote Handle Lever, or Difficult to lock them.pdf (159.3 KB, 422 views)

03-09-2013, 05:16 PM

#11

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

update

Attached Files

UNUSUAL ENGINE NOISE AFTER A COLD ENGINE START.pdf (115.9 KB, 714 views)

Whining sound from the engine compartment after starting a cold engine.pdf (88.5 KB, 487 views)

Wrong indication i-ELOOP gauge when driving with auto cruise ON.pdf (133.8 KB, 667 views)

Rattle Noise from Passenger side Instrument Panel.pdf (325.5 KB, 1222 views)

CX-5 Wind Noise from Rear Door while driving at 40 km_h.pdf (150.5 KB, 498 views)

03-09-2013, 05:17 PM

#12

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

more..

Attached Files

Engine noise while driving.pdf (238.8 KB, 610 views)

Rear mount camera does not operate.pdf (41.2 KB, 915 views)

Noise from Front Door Checker Installation Location.pdf (88.9 KB, 400 views)

Outer mirror base cover discolors to white.pdf (392.0 KB, 423 views)

CX-5 Rattle noise from front door window glass.pdf (198.1 KB, 2014 views)

03-09-2013, 05:17 PM

#13

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

more..

Attached Files

Refinishing of Soul Red Metallic.pdf (16.3 KB, 2430 views)

Clinking-Hissing noise from the front right side of vehicle.pdf (262.1 KB, 536 views)

Mazda 6 DTC U0121 (ABS_DSC control module communication failure) stored during PCM reprogramming.pdf (144.5 KB, 539 views)

Multi-Model Maintenance Monitor Best Practice.pdf (713.8 KB, 414 views)

Multi-Model Tire Pressure Maintenance Monitor.pdf (1.32 MB, 878 views)

03-11-2013, 04:37 AM

#14

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

cont..

Attached Files

TOM-TOM Guidance volume Check.pdf (43.5 KB, 324 views)

Mazda 6 Vehicle speed change with MRCC.pdf (88.0 KB, 629 views)

MZ6 Rear Door Lock Inoperative due to Freeze.pdf (63.3 KB, 361 views)

CX-5 Knocking or Squeaking Noise from Front Strut Bearing.pdf (73.0 KB, 2181 views)

Mazda 6 Noise when sliding front power seat.pdf (277.1 KB, 1289 views)

03-11-2013, 10:23 PM

#15

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

more..

Attached Files

Noise from right rear of vehicle when closing rear door_trunk lid or driving on rough road.pdf (253.7 KB, 468 views)

Sensor aiming after windshield removal.pdf (32.1 KB, 418 views)

Long cranking and rough idling after cold start at low ambient temperatures.pdf (198.0 KB, 540 views)

MZ6 Unusual noise when vehicle is started with steering wheel fully turned to driver-side.pdf (92.4 KB, 409 views)

MZ6 (Video File)Unusual noise when vehicle is started with steering wheel fully turned to driver.pdf (711.0 KB, 274 views)

03-15-2013, 02:36 PM

#16

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

new ones added..

Attached Files

CX-5 Outer mirror vibration when driving on highway.pdf (300.0 KB, 4219 views)

MZ3 Handling Caution for Trailer Transportation.pdf (191.5 KB, 302 views)

CX-5 Unusual noise when vehicle is started with steering wheel fully turned to driver-seat side.pdf (81.6 KB, 1150 views)

CX-5 Video Unusual noise when vehicle is started with steering wheel fully turned to driver-seat.pdf (629.4 KB, 1076 views)

CX-5 Front seat back trim coming apart at seams.pdf (75.1 KB, 946 views)

03-19-2013, 06:31 PM

#17

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

New Added, Oct, 2013.

Attached Files

CX-5 Noise from under the driver seat.pdf (172.4 KB, 614 views)

MZ6 NEW MODEL SERVICE CAUTIONS.pdf (319.7 KB, 424 views)

MZ3 NEW MODEL SERVICE CAUTIONS.pdf (242.1 KB, 608 views)

MZ3 Oil Maintenance Monitor.pdf (124.8 KB, 660 views)

HANDS-FREE BLUETOOTH MODULE TROUBLESHOOTING PROCEDURE.pdf (115.9 KB, 508 views)

05-17-2013, 03:02 PM

#18

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

Mazda 6 Radar Cruise Control TSB..

There appears to be an issue with Radar Sensor in Grille on new Mazda 6.

Quote:

Some radar sensors produced in a specified period are defective and they incorrectly detect as if dirt is adhered on the radar

Attached Files

Radar Cruise Control issue with DTC C1A67-92.pdf (87.1 KB, 1662 views)

TomTom NAVIGATION FUNCTIONALITY CONCERNS.pdf (289.0 KB, 648 views)

SUNROOF WATER LEAK AFTER HIGH PRESSURE CAR WASH.pdf (127.2 KB, 1411 views)

CX-5 Driver-side Seat slowly moves down by itself.pdf (98.0 KB, 651 views)

CX-5 Rattling Noise from Rear Center Seat Back when driving on rough road.pdf (133.8 KB, 394 views)

05-29-2013, 12:42 AM

#19

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

DO NOT Grease Stabilizer Bar Bushes on New Mazda's

for the first time Mazda are using a new type of Stabilizer Bush on front and rear Bars for all new CX-5 and new Mazda 6..

They now use a 'grip type bush'..

This TSB is to inform Dealers NOT to use any grease.

Attached Files

Stabilizer Bush of Front and Rear.pdf (31.6 KB, 385 views)

09-11-2013, 05:41 AM

#20

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

New for 2014 BM MAZDA 3....

Attached Files

MZ3 Navigation system SD Card handling notes.pdf (178.8 KB, 473 views)

MZ3 New Special Service Tool for Mazda3 (BM).pdf (137.1 KB, 617 views)

MZ6 Rear door weatherstrip out of position.pdf (223.4 KB, 1093 views)

CX-5 Front Brake Judder.pdf (72.2 KB, 799 views)

09-30-2013, 08:39 PM

#21

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

I can't recall, but remember reading somewhere there was an owner who was having repeated issues with Auto Trans Oil Pan leaking after being @ a Mazda Dealer many times...

It 'could be' that the Oil Pan BOLTS also need renewing...?

Anyway, for the all new SKYACTIV Auto Trans..

As is the case with ALL new Skyactiv Auto Transmissions, the transmission Oil Pan Bolts must be renewed whenever the Trans oil pan is removed..

..see M tip..

This is the Part Number for the 16 SA Auto Trans Oil Pan BOLTS...

9YA0-10-615A Bolt...16 used.

Attached Files

AT Trans Oil Pan Bolts.pdf (226.4 KB, 465 views)

06-03-2014, 05:36 AM

#22

ASH8

Super Moderator

Thread Starter

Join Date: Apr 2005

Location: Australia

Posts: 10,861

Likes: 170

Received 316 Likes on 225 Posts

NEW TSB's FOR 2014

OK, Here are all new 2014 TSB's for ALL new SA Mazda KE CX-5, GJ Mazda 6 and BM Mazda 3...

They are for all (most) Mazda world markets, as these are from Mazda Japan they include many other nations where Mazda's are sold.

IF you are in North America, please check the Right Top of PDF to see IF TSB applies to your region or not...

ATM as I do not have time to 'triple check' everything I post to update remove or delete with any previous Skyactiv Bulletins listed here or TSB Revisions. I will leave it to the member to verify IF the Bulleting applies to YOUR VIN Number or Model.

There are also some SA Diesel TSB's for Europe and Australia.

Attached Files

Automatic Transaxle (ATX) Inspection by Fail-Safe Function.pdf (140.7 KB, 372 views)

BM Buzzing noise from around driver-side dashboard.pdf (236.5 KB, 549 views)

BM CD Player Display Concerns.pdf (398.7 KB, 408 views)

BM Commander Switch caves in.pdf (73.2 KB, 386 views)

BM Handling Caution of Active Driving Display (ADD).pdf (99.3 KB, 316 views)